Skip to content
FREE OTTAWA / GATINEAU ASSEMBLY & DELIVERY ON ORDERS OVER $199. FREE SHIPPING OVER $999*
FREE OTTAWA / GATINEAU ASSEMBLY & DELIVERY ON ORDERS OVER $199. FREE SHIPPING OVER $999*
Section
Drop element here!

BOSTON BACON FATTIES

ORIGINALLY POSTED ON WEBER

PREP TIME

30 Mins

COOK TIME

1.5 - 2 Hrs.

FEEDS

8

DIFFICULTY

Medium

INGREDIENTS

For the Recipe:Table header 1
8Sweet Italian sausages, each about 115 grams, casings removed
25 grams
Finely grated Parmigiano-Reggiano® cheese
32
Thick-cut bacon slices, about 1.4 kilograms
65 gramsPacked, drained marinated artichoke hearts, chopped
55 gramsPacked, drained marinated sun-dried tomatoes, chopped
70 gramsRoasted red bell pepper (from a jar), chopped
Special equipment
1 Large
Handful hickory wood chips
Instant-read thermometer

DIRECTIONS

  • Soak the wood chips in water for at least 30 minutes.
  • Prepare the grill for indirect cooking over low heat (120°C to 180°C). 
  • Mix the sausage and cheese thoroughly but gently. Divide the meat into two equal portions.
  • Lay a large sheet of wax paper on a work surface. On the wax paper, using half of the bacon slices (eight slices going in one direction and eight in the other), weave a tight square, as if you are making a lattice pie crust. The finished size should be about 28 × 28 centimetres (don’t be afraid to stretch the bacon strips a little to fit). 
  • Lay a large sheet of wax paper on another work surface. Press one of the meat portions into a 23 centimetre square. About 5 centimetres from the side nearest you, arrange half of the artichokes, half of the tomatoes and half of the peppers in parallel, horizontal lines, leaving about 2.5 centimetres at each end. Lifting the waxed paper under the sausage mixture, roll up the mixture tightly around the vegetables and then pinch the ends to seal everything in. This should look like a small meat loaf. Place this meat loaf at the edge of the bacon weave closest to you. Using the wax paper underneath the bacon to help, roll the bacon blanket around the sausage, tucking the ends in as you go. Set aside, seam-side down. Repeat with the remaining ingredients, making a second wrapped fatty.
  • Drain and add the wood chips to the charcoal or to the smoker box of a gas grill, following the manufacturer’s instructions, and close the lid. When smoke appears, grill the fatties over indirect low heat, with the lid closed, until an instant-read thermometer inserted into the thickest part of the meat reaches 68°C, 1½ to 2 hours. Remove from the grill and let rest for 10 minutes (the internal temperature will rise a few degrees during this time). Cut into slices about 2.5 centimetres thick and serve right away.

MAKE THIS RECIPE EASILY WITH